2003 MAZDA MPV Recalls (4)

Campaign:
03V053000 on 02/23/2003
Component:
Exterior lighting:fog lights
Manufactured:
11/11/2001 - 01/20/2003
Affected:
5,400
Defect:
On certain mini vans equipped with front fog lights,the fog light bulb socket may have been installed improperly.
Consequence:
if the vehicle continues to be used with this condition, the bulb socket and the wiring harness may separate from the fog light housing if exposed to shock and/or vibration and drop inside the bumper. should this occur, the operation of the fog light may then cause the bumper to burn.
Correction:
Dealers will inspect the installation condition of the fog light bulb assembly, and repair it when necessary. owner notification began march 31, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mazda at 1-800-222-5500.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V206000 on 06/05/2003
Component:
Exterior lighting:fog lights
Manufactured:
11/25/2001 - 02/27/2003
Affected:
64,000
Defect:
On certain mini vans and passenger vehicles, the socket holder in the fog lights is installed in the lamp casing using pressure. during operation of the fog light, the heat from the bulb can expand the socket holder. the expansion can force the socket holder rearward. after repeatedly being subject to this expansion, if the fog light is also subjected to vibration during vehicle operation, the socket holder with the bulb holder and the wiring harness may separate from the fog light casing.
Consequence:
Should this occur, the bulb socket and the harness can drop inside the bumper and possibly but rarely, the heat generated by the bulb can cause the bumper to burn.
Correction:
Dealers will install a spring to prevent the socket holder from separating from the lamp case. owner notification began on july 14, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 1103f.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V109000 on 03/09/2004
Component:
Equipment:other:labels
Manufactured:
11/25/2001 - 06/29/2003
Affected:
350
Defect:
Certain minivans fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection." some of these vehicles were produced with air bag warning labels intended for the canadian market. thus, the labels contain warnings in both english and french. as a result, the area of the english warning is only 16 square centimeters, as opposed to the 30 square centimeters required by the standard.
Correction:
Owners will be provided with air bag caution labels and installation instructions which were mailed on july 22, 2004. owners should contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 1804c.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V282000 on 06/16/2004
Component:
Equipment:other:labels
Manufactured:
08/19/2003 - 05/05/2004
Affected:
20,000
Defect:
The tire inflation pressure indicated on the vehicle certification label is not correct. the labels show the maximum tire pressure as 240 kpa/32 psi when it should be shown as 240 kpa/35 psi. as a result of this error, the load ratios for the 205/65r15 94h and the 215/60r16 95h tires exceed the levels permitted by fmvss 120.
Consequence:
If the tire is operated in an under-inflated condition, the load carrying capacity of the vehicle may be compromised, increasing the risk of a crash.
Correction:
Owners will be provided with a corrected label that they can apply to their vehicle, or they can have a dealer install the label, if desired. the recall began on july 16, 2004. owners should contact mazda at 1-800-222-5500, option #4.
Notes:
Mazda recall no. 2140f.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

2003 MAZDA MPV TSBs (67)

Bulletin:
0901402
Component:
350000 equipment
Summary:
Accessory rear cargo net hooks detach. *tt
Bulletin:
0101203
Component:
061000 engine and engine cooling:engine
Summary:
Tappet (tick) noise from engine. *tt
Bulletin:
0900403
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid line repair procedure. *tt
Bulletin:
0400103
Component:
030000 service brakes, hydraulic
Summary:
Front brake clunking noise. *tt
Bulletin:
0102103
Component:
061000 engine and engine cooling:engine
Summary:
Stick / slip noise from engine. *tt
Bulletin:
0700403
Component:
062000 engine and engine cooling:cooling system
Summary:
Corrosion on rear heater pipe. *ph warranty extension. *tt
Bulletin:
0004180
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
B29 and later powertrain control module (pcm) calibration update information. repair information review1. *tt
Bulletin:
0900104
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Port or dealer installed auto-dimming (electro-chromic) mirror, with electronic compass, ambient temperature. *mr
Bulletin:
0700104
Component:
062000 engine and engine cooling:cooling system
Summary:
Air temperature output difference between center dash vents. *mr this bulletin replaced the previous bulletin issued on 02/12/04. *tt
Bulletin:
0500603
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble code (dtc) p0706. this bulletin supersedes 01-023/03 issued 10/15/03. *tt
Bulletin:
0500104
Component:
103000 power train:automatic transmission
Summary:
Automatic transaxle may exhibit shift shock while the engine warms from cold to normal. *tt
Bulletin:
0901904
Component:
132000 visibility:glass, side/rear
Summary:
Loose rear quarter window glass. *mj
Bulletin:
0101904
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes (dtcs) p2404 / p0446. *tt
Bulletin:
0902604
Component:
353000 equipment:electrical
Summary:
Speedometer replacement procedure. *tt
Bulletin:
0102504
Component:
111000 electrical system:battery
Summary:
Battery test procedure requirements. *tt
Bulletin:
0902904
Component:
021000 suspension:front
Summary:
Popping noise from front suspension when driving over bumps. *tt
Bulletin:
08022004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release. *tt
Bulletin:
0700404
Component:
062000 engine and engine cooling:cooling system
Summary:
Lack of warm air from front heater. *tt
Bulletin:
08262004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/26/2004. *tt
Bulletin:
0903304
Component:
120000 exterior lighting
Summary:
Rear combination lamp removal caution. *tt
Bulletin:
2204H
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
The positive crankcase ventilation (pcv) hose may fail, causing rough idling and/or the malfunction indicator lamp (mil) to illuminate. emission recall 2204h letter to dealer; attachment i dealer information; attachment ii; attachment iii
Bulletin:
010104
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
It is possible that the soldering strength on a terminal in the fan control module may be insufficient, causing a crack during use. fan control module special service program (ssp)60. *nm
Bulletin:
0103504
Component:
061000 engine and engine cooling:engine
Summary:
Engine pinging during acceleration and/or light throttle cruising. *tt
Bulletin:
0102103
Component:
061000 engine and engine cooling:engine
Summary:
Metal snap or popping noise from engine. *eh
Bulletin:
00204
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emmissions and reciver adapters. *eh
Bulletin:
0700304
Component:
060000 engine and engine cooling
Summary:
Coolant seepage from rear heater pipe. *tt
Bulletin:
0500105
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
O/d off indicator light flashing / malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p0706. *tt
Bulletin:
0901405
Component:
220000 seats
Summary:
Rattling noise from 2nd-row seats. *sc
Bulletin:
0901105
Component:
133000 visibility:power window devices and controls
Summary:
Power windows inoperative - blown fuse. to include 2006 mazda mpv. *tt
Bulletin:
0904004
Component:
162300 structure:body:door
Summary:
Power sliding door (psd) system service tips due to inoperative or improper power sliding door (psd) operation. *tt
Bulletin:
0903804
Component:
162300 structure:body:door
Summary:
Power sliding door (psd) drive module removal / installation procedures. *tt
Bulletin:
0103305
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Engine no start in extreme cold weather. *tt
Bulletin:
0902605
Component:
162300 structure:body:door
Summary:
Power sliding door (psd) re-opens after starting to close and latch. *tt
Bulletin:
0105406
Component:
061000 engine and engine cooling:engine
Summary:
Engine hard to start, runs rough. *kb
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
0500304
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Mazda special program (msp03) - shift shock - transmission control module (tcm) reflash. vehicles built from 4/1/03 through 1/26/04. *nj
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
00-004/12
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
09-001/16
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Summary to be provided on a future date.
Bulletin:
00-004-16-3237
Component:
350000 equipment
Summary:
Raising a vehicle with a jack can be dangerous if not done properly. the vehicle can slip off the jack and seri-ously injure someone. in this service information, some important warnings and cautions have been taken from the owner's manual.
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
07-002-13-2842
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
05-007-14-2918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
The vehicle's automatic transaxle (atx) may exhibit shift shock while the engine warms from cold to normal operating temperature. the symptom is intermittent, it does not occur all the time. the shift shock usually occurs during 1-2 or 2-3
Bulletin:
05-006-14-2917
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
The vehicle's automatic transaxle (atx) may exhibit shift shock while the engine warms from cold to normal operating temperature. the symptom is intermittent, it does not occur all the time. the shift shock usually occurs during 1-2 or 2-3
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
01-003-15-3014
Component:
350000 equipment
Summary:
Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
Bulletin:
09-001-16-3113
Component:
355200 equipment:other:owners/service/other manual
Summary:
If the immobilizer unit lc62-67-5g2* or dc69-67-5g2* needs to be replaced with a new one, these parts are no longer available. new alternative service parts kits are now available, including alternative immobilizer unit bj3d-67-5g2l or tc91
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
07-002-18-3432
Component:
353600 equipment:air conditioner
Summary:
A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
RF-18-03
Component:
060000 engine and engine cooling
Summary:
Exhaust pipe gasket open end: there has been some concern with the open end of hoop design being considered a defect in the gasket for p/n aj17-40-305. the end of this ?hoop? is intentionally modified to press fix the gasket on the exhaust
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy